Frymaster Dean SM35 User Manual

Dean, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. MAY 2007 24-Hour Service Hotlin

THIS PAGE INTENTIONALLY LEFT BLANK.

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 Receiving and Unpacking Equipment A. Check that the container is up

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-2 2.2 General (cont.) Dean Super Marathon Series gas fryers are energy effi

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-3 2.5 Pre-Installation DANGER No structural material on the fryer should b

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-4 2.5 Pre-Installation (cont.) C. Installation Standards 1. INSTALLATION

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 2: IMPORTANT INFORMATION 2-5 2.7 Air Supply and Ventilation DANGER This appliance must be installed

THIS PAGE INTENTIONALLY LEFT BLANK.

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-1 3.1 Installing the Fryer A. Initial Installation: If installed with

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-2 3.2 Leg and Caster Installation (cont.) 4. Proceed to Step 3.3, Leve

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-3 3.3 Leveling the Fryer (cont.) B. If the floor is uneven or has a d

Please read all sections of this manual and retain for future reference. NOTICE This appliance is intended for professional use only and is to be

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-4 3.3 Leveling the Fryer (cont.) NOTE: The installation must be inspect

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-5 3.4 Gas Connections (cont.) The gas supply (service) line must be the

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-6 3.4 Gas Connections (cont.) Rigid Connections Check any installer-su

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-7 3.4 Gas Connections (cont.) WARNING Use a diluted soap solution to f

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-8 3.4 Gas Connections (cont.) F. After hook up, bleed the gas line of

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-9 3.6 Gas Inputs Nominal Heat Inputs (Qn), Gas Type, Orifice Size (appl

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-10 3.7 Gas Conversion Procedures See gas valve illustration below and g

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-11 3.7 Gas Conversion: Procedures (cont.) Vessel AssemblyGas ValveMani

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 3: INSTALLATION INSTRUCTIONS 3-12 3.9 Electrical Connections Fryers without built-in filtration do no

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-1 4.1 Initial Start-up WARNING The on-site supervisor is responsible for

DANGER The front ledge of the fryer is not a step. Do not stand on the fryer. Serious injury can result from slips or contact with the hot oil.

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-2 4.1.1 Pilot Lighting Procedures, Standing Pilot Only Initial Pilot Lig

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-3 4.2 Boil-Out Procedure DANGER Never leave the fryer unattended during

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-4 4.2.1 Thermostat-Equipped Fryers (cont.) WARNING Water or boil-out s

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 4: FRYER OPERATIONS 4-5 4.3.1 Filling Fryer with Cooking Oil/Shortening—Operating Thermostat (c

THIS PAGE INTENTIONALLY LEFT BLANK.

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 5: PREVENTATIVE MAINTENANCE 5-1 5.1 General DANGER Never attempt to clean the fryer during th

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 5: PREVENTATIVE MAINTENANCE 5-2 5.1.3 Periodic/ Annual The fryer should be inspected and adjus

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 6: TROUBLESHOOTING 6-1 6.1 General DANGER Hot cooking oil/shortening will cause severe burns.

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 6: TROUBLESHOOTING 6-2 6.3 Main Burner Malfunctions A. Main burner will not come "ON&qu

DEAN MILLIVOLT SERIES GAS FRYERS (NON-CE) CHAPTER 6: TROUBLESHOOTING 6-3 6.4 Wiring Diagrams Honeywell Millivolt Gas Valve WiringThermostatOper

Dean Millivolt Gas Fryers (Non-CE) Installation & Operation Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 1.1 After Purchase

Dean, 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana 71135-1000 Shipping Address: 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-8

Dean Millivolt Gas Fryers (Non-CE) Installation & Operation Manual TABLE OF CONTENTS (CONT.) Page # 5. PREVENTATIVE MAINTENANCE 5-1

THIS PAGE INTENTIONALLY LEFT BLANK.

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 1: INTRODUCTION 1-1 1.1 After Purchase In order to improve service, have the following chart filled in

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 1: INTRODUCTION 1-2 1.4 Safety Information Before attempting to operate your unit, read the instructi

DEAN MILLIVOLT GAS FRYERS (NON-CE) CHAPTER 1: INTRODUCTION 1-3 1.5.1 Definitions (cont.) B. Qualified Installation Personnel 1. Qualified insta