Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. 24-Hour Service Hotline 1
1-7 Remove the six screws inthe faucet mounting plate.Disconnect water line atthis compression fitting.Remove this nut to separate thefaucet from the
1-8 5. Remove the four bolts securing the motor mount to the frame, then remove the “motor and mount assembly” from the unit. NOTE: It is possible
1-9 Burners Blower and
1-10 Remove these four screws.Remove screws along the top edge ofcontrol panel and dismount the panel.Remove thesescrews (on bothsides) and removeback
1-11 1.4 Troubleshooting Problems with this equipment maybe grouped into five broad categories: 1. Failure or malfunction of a Power-Supply System c
1-12 used, add ⅛-cup of baking soda to the water each time the cookpot is emptied and refilled. NOTE: Do not use deliming solution to clean these uni
1-13 1.4.5 How the Basket Lift System Works When the start switch is pressed to start the cooking cycle, logic circuits in the controller activate t
1-14 PROBLEM PROBABLE CAUSES CORRECTIVE ACTION Continued from previous page. C. Failed solenoid, failed computer, or broken/loose wiring. Test 1:
1-15 PROBLEM PROBABLE CAUSES CORRECTIVE ACTION B. Failed controller. B. Replace controller. Burner will not light; trouble light is on, blower is
1-16 PROBLEM PROBABLE CAUSES CORRECTIVE ACTION Water boils in simmer mode. A. Failed/shorted temperature probe. Test: Check for shorted probe circ
DANGER IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE, OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY, OR DEATH. READ THE INSTALLATION
1-17 1.4.7 Probe Resistance Chart and Wiring Diagrams RESISTANCE CHART FOR USE WITH 806-4764 PROBE F OHMS C F OHMS C F OHMS C F OHMS C 32 486.0 0.
1-18 WIRING DIAGRAMS GPC, GPCB, GPCR and GPCRB
1-19 GPC, GPCB, GPCR and GPCRB (Noodles)
1-20 GPC, GPCB, GPCR and GPCRB (CE)
PASTA MAGIC GAS COOKERS GPC, GPCB, GPCR AND GPCRB SERVICE AND PARTS CHAPTER 2: PARTS LIST 2-1 2.1 Accessories 53482761 ITEM PART # COMPONENT 1
2-2 2.2 Basket Lift Components 11DETAIL A2316 20 39312916435 2136273313413828374426281442401518191830103192522177431612532249SEE DETAIL A34
2-3 2.2 Basket Lift Components cont. ITEM PART # COMPONENT 1 Motor, Basket Lift 807-0107 120 VAC 807-0108 240 VAC 2 807-0124 Bushing, Plasti
2-4 2.3 Cabinetry 2.3.1 GPC/GPCB
2-5 2.3.1 GPC/GPCB cont. ITEM PART # COMPONENT 1 108-1434 Door Assembly, 18.66-inch x 19.85-inch (does not include handle) 106-4067 Door Pin A
2-6 2.3.2 GPCR/GPCRB Batteries
i GAS COOKERS GPC, GPCB, GPCR and GPCRB SERVICE & PARTS MANUAL TABLE OF CONTENTS CHAPTER 1: Service Procedures 1.1 Functional Description ...
2-7 2.3.2 GPCR/GPCRB Batteries cont.ITEM PART # COMPONENT Cabinet Assemblies 108-2146 Double GPC Cooker/Cooker Stainless (Use 108-2154 for CR)
2-8 2.4 Combustion System Components
2-9 2.4 Combustion System Components cont. ITEM PART # COMPONENT Cookpot Complete Assemblies (does not include burner (see item 20)) 108-1420
2-10 2.5 Control Box and Related Components
2-11 2.5 Control Box and Related Components cont. ITEM PART # COMPONENT Component Assembly Boxes 108-1506 Component Box Assy, 120V Non-BL
2-12 2.6 Controllers and Control Panel Components ITEM PART # COMPONENT 1 108-1444 Controller, SMS III GPC/GPCB/GPCR/GPCRB 2 807-1704 Lamp,
2-13 2.7 Cookpot, Rinse Tank, and Associated Components 2.7.1 Cookpot and Rinse Tank Components (Other than Cookpot Insulation) 5632178129121011 1
2-14 2.7.2 Cookpot Insulation 451291011123876NOTE: Cookpot shown for reference only.Refer to Page 2-13 for cookpot components.Refer to Page 2-8 for
2-15 2.8 Drain Components
2-16 2.8 Drain Components cont. ITEM PART # COMPONENT 1 823-7996 Handle, Drain Valve GPC 2 814-0047 Sleeve, Handle Valve Red 3 810-1825 Valv
1-1 GAS COOKERS GPC, GPCB, GPCR AND GPCRB SERVICE AND PARTS CHAPTER 1: SERVICE PROCEDURES 1.1 Functional Description The GPC, GPCB, GPCR and GPCRB
2-17 2.9 Gas Supply System Components
2-18 2.9 Gas Components cont. ITEM PART # COMPONENT 1 810-0691 Tube, Vent 2 Valve, Honeywell Gas (Non-CE) 826-1122 Natural 826-1123 Propane
2-19 2.10 Water Supply System Components Item 6 (nipple) is threaded into item 1 (solenoid).Item 3 (nut) is threaded onto item 6 to secureitem 14 (
2-20 ITEM PART # COMPONENT 1 806-5565 Valve Assembly, Solenoid 2 826-1374 Screw, #10 x ½-inch Hex Head (Pkg. of 25) 3 809-0454 Nut, ½-inch Con
Shipping Address: 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318-219-7140 (Tech Support) 1-318-219-7135 PRIN
1-2 SMS III Controller The GPC, GPCB, GPCR and GPCRB controllers do not have a ten-time warm up cycle as previous models did, but instead use a Fenwa
1-3 the basket lift arms down, a cam attached to the left motor eventually loses contact with a roller-activated microswitch and power to the motors a
1-4 1.2 Accessing Equipment for Servicing DANGER Moving this equipment while it is filled with hot water may cause spilling or splattering of the ho
1-5 1.3.3 Replacing a Water-Level Sensor or the Temperature Probe 1. Drain the cookpot and disconnect the cooker from the electrical power supply.
1-6 2. Disconnect the solenoid leads at the push-on connectors. Disconnect solenoid and regulator subassembly at the compression fittings on the wa
Comments to this Manuals