Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. 24-Hour Service Hotline 1-
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-2 2.2 General Qualified, licensed, and/or authorized installation or servi
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-3 2.3 Principles of Operation The incoming gas flows through orifices and
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-4 2.5 Pre-Installation (cont.) B. Clearances: The fryer area must be kep
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-5 2.6 Air Supply and Ventilation DANGER This appliance must be installed
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-1 3.1 Installing the Fryer Decathlon 65 Series fryer systems are shipped in sections.
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-2 Figure 5: Clamp the fryers together to facilitate mounting securing bracket
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-3 3.1 Installing the Fryer (cont.) DANGER Fryers must be at room temperature and em
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-4 3.2 Gas Connections (cont.) DANGER If gas odors are detected, the gas supply MUS
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-5 3.2 Gas Connections (cont.) C. Manual shut-off valve: This gas service supplier-
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-6 3.2 Gas Connections (cont.) I. Flexible Couplings, Connectors and Casters: 1.
NOTICE This appliance is intended for professional use only and is to be operated by qualified personnel only. A Frymaster/Dean Factory Authorized
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-7 3.3.1 Specifications 3.3.1.1 Adjustments to Different Gas Types Gas Adjustments
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-8 3.3.2 Gas Conversion Procedures (cont.) Contact factory with the following inform
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-1 4.1 Initial Start-up WARNING The on-site supervisor is responsible for ensuri
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-2 4.1.1 Pilot Lighting Procedures, Electronic Ignition Systems Initial Pilot Li
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-3 4.2 Boil-Out Procedure DANGER Never leave the fryer unattended during the bo
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-4 4.2 Boil-Out Procedure (cont.) G. The burners will heat the boil-out solutio
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-5 4.3 Final Preparation WARNING NEVER set a complete block of solid shortenin
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-1 WARNING Drawings and photos used in this manual are intended to illustrate
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-2 5.3 Filter Preparation On initial installation and before each use, clean t
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-3 5.2.2 Filter Unit Types (cont.) FILTER LEAF A filter leaf is a fine mesh s
DANGER Improper installation, adjustment, maintenance or service, and unauthorized alterations or modifications can cause property damage, injury, or
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-4 5.2.3 Assembling the Filter FILTER PAPER AND HOLD DOWN RING 1. Place the
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-5 5.2.4 Assembling the Filter (cont.) 4. Sprinkle 8 ounces (227g) of filte
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-6 5.2.5 Assembling the Filter (cont.) FILTER LEAF 1. Remove the filter pan
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-7 5.2.6 Assembling the Filter (cont.) 6. Sprinkle 8 ounces (227g) of filter
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-8 5.2.7 Installing the Filter 9. Slide the filter inside the fryer cabinet.
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-9 5.3.2 Filtering Tools Assemble tools to be used for filtering. These are s
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-10 5.4 Operating the Filter 5.4.1 Pan Preparation and Operation See Section
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-11 5.4.2 Pan Preparation and Operation (cont.) 4. After ensuring the filter
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-12 5.4.3 Filter Operation 6. Oil will begin to pump from the filter pan into
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-13 5.4.4 Filter Operation (cont.) 9. After all oil is pumped back into the
FPD65 Series Gas Fryers Installation & Operation Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 1.1 After Purchase 1-1 1.2
DECATHLON SERIES GAS FRYERS CHAPTER 5: UNDER FRYER FILTER (SUFF/UFF) FILTRATION 5-14 5.4.5 Filter Operation (cont.) 12. Do not allow crumbs to a
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-15 5.5 Optional Filter Hose and Wand Operation Some frying systems come equip
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-16 5.6 Hose and Wand Operation (cont.) 5. The oil will start to flow immedi
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 6: PREVENTIVE MAINTENANCE 6-1 6.1 General DANGER Never attempt to clean the fryer during the cooking
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 6: PREVENTIVE MAINTENANCE 6-2 6.1.3 Periodic/ Annual The fryer should be inspected and adjusted perio
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 6: PREVENTIVE MAINTENANCE 6-3 6.1.3 Periodic/ Annual (cont.) • Check filtration system integrity as
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-1 7.1 General DANGER Hot cooking oil/shortening will cause severe burns. Never
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-2 7.2 Pilot Burner Malfunction (cont.) 3. Check all connections for cleanliness
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-3 7.3 Main Burner Malfunctions (cont.) D. Fryer will not reach the temperature
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-4 7.4 Wiring Diagram, Main
FPD65 Series Gas Fryers Installation & Operation Manual TABLE OF CONTENTS (CONT.) Page # 5. FILTRATION OPERATION 5-1 5.1 General
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-5 7.5 Wiring Diagram, Filter
THIS PAGE INTENTIONALLY LEFT BLANK
Frymaster, 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318-688-2200 FAX (Tech Support) 1-318-219-7135 PRINTED
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-1 1.1 After Purchase In order to improve service, have the following chart filled in
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-2 1.4 Computer Information (cont.) The user is cautioned that any changes or modifi
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-3 1.6 Service Personnel 1.6.1 Definitions A. Qualified and/or Authorized Operati
FRYMASTER FPHD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 Receiving and Unpacking Equipment A. Check that the containers are u
Comments to this Manuals